Click here to make tpub.com your Home Page

Page Title: Home Page

• TECHNICAL MANUAL
• WARNING
• TABLE OF CONTENTS
• LIST OF ILLUSTRATIONS
• LIST OF ILLUSTRATIONS - CONT
• CHAPTER 1 INTRODUCTION
• Figure 1-1. Fork lift tuck with shipping dimensions, right side view.
• Figure 1-2. Fork lift truck, left side view
• Figure 1-3. Wiring diagram
• Differences in Models
• CHAPTER 2 OPERATING INSTRUCTIONS
• Figure 2-1. Controls and instruments (sheet 1 of 2).
• Figure 2-1. Control and instruments (sheet 2 of 2)
• Figure 2-3. Engine starting instructions
• Lifting and Transporting a Load
• Figure 2-5. Lifting operation.
• Depositing a Load
• Section II. OPERATING UNDER UNUSUAL CONDITIONS
• CHAPTER 3 OPERATOR/CREW MAINTENANCE INSTRUCTIONS
• Table 3-1. Operator/Crew Preventive Maintenance Checks and Services - Continued
• Table 3-1. Operator/Crew Preventive Maintenance Checks and Services - Continued
• Table 3-1. Operator/Crew Preventive Maintenance Checks and Services - Continued
• Section IV. OPERATOR MAINTENANCE OF TRUCK
• Fuel Lines
• Engine Assembly
• Transmission
• Hydraulic Reservoir
• Figure 3-6. Hydraulic reservoir
• CHAPTER 4 ORGANIZATIONAL MAINTENANCE INSTRUCTIONS
• Table 4-1. Freezing Points, Composition and Specific Gravities of Military Antifreeze Materials
• Table 4-2. Maintenance and Operating Supplies
• Section II. MOVEMENT TO A NEW WORKSITE
• Section V. ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES
• Table 4-3. Organizational Preventive Maintenance Checks and Services - Continued
• Section VI. ORGANIZATIONAL MAINTENANCE TROUBLESHOOTING
• Table 4-4. Organizational Maintenance Troubleshooting
• Table 4-4. Organizational Maintenance Troubleshooting - CONT
• Section VII. RADIO INTERFERENCE SUPPRESSION
• Section IX. PANELS. COWLS AND PLATES
• Cowls
• Side Panels
• Section X. SEAT ASSEMBLY
• Section XI. INSTRUMENT PANEL
• Figure 4-6. Instrument panel components, exploded view.
• Figure 4-7. Instrument panel, exploded view. 17
• Section XII. HYDRAULIC LIFT COMPONENTS
• Figure 4-8. Hydraulic system diagram.
• Hydraulic Lines and Fittings
• Figure 4-10. Lift chains and carriage.
• Carriage, Backrest and Forks
• Figure 4-12. Carriage. removal and insulation.
• Figure 4-13. Spanning mast channels
• Tilt Cylinders
• Figure 4-17. Tilt cylinder yoke, install view.
• Cluster Cylinder
• Figure 4-19. Mast assembly (model ACC40-24PS180), exploded view.
• Figure 4-20. Mast assembly (model ACC40-24PS100), exploded view.
• Single Lift Cylinder (Model ACC40-24PS180)
• Control Valve Levers
• Figure 4-22. Control valve levers, installed view.
• Hydraulic Filter
• Installation.
• Hydraulic Reservoir
• Removal
• Figure 4-27. Hydraulic reservoir, exploded view.
• Section XIII. ELECTRICAL SYSTEM
• Lights
• Installation.
• Horn
• Figure 4-32. Horn and relay, installed view.
• Wiring
• Alternator
• Figure 4-35. Alternator, installed view.
• Starter
• Distributor
• Cleaning, Inspection and Repair.
• Figure 4-41. Spark plugs and coils, exploded view.
• Figure 4-42. Distributor, explode view.
• Figure 4-43. Flywheel timing marks.
• Spark Plugs
• Section XIV. FUEL SYSTEM
• Figure 4-45. Fuel system exploded view.
• Carburetor
• Choke adjustment.
• Governor
•  Fuel Filter
• Accelerator Pedal and linkage
• Fuel Tank
• Section XV. COOLING SYSTEM
• Radiator
• Figure 4-53. Radiator and hoses, removal and installation
• Thermostat
• Section XVI. EXHAUST SYSTEM
• Section XVII. STEERING SYSTEM
• Tie Rods and Drag Link
• Removal.
• Steering Cylinder
• Section XVIII. ENGINE
• Manifolds
• Figure 4-60. Cylinder head, exploded view
• Figure 4-62. Checking cylinder head for flatness crosswise.
• Figure 4-64. Valve chamber cover, removal and installation
• Engine Valves
• Section XIX. WHEELS
• Removal
• Section XX. BRAKES
• Figure 4-70. Brake pedal and linkage, exploded view.
• Inspection.
• Service Brake Wheel Cylinder
• Master Cylinder
• Parking Brake Lever and Linkage
• Figure 4-76. Parking brake lever, installed view.
• Figure 4-77. Parking brake cable, installed view.
• Parking Brake
• Section XXI. DRIVE AXLE
• Differential
• Section XXII. TRANSMISSION
• Control Lever and Linkage
• Figure 4-84. Transmission control adjustment.
• Neutral Start Switch
• APPENDIX A REFERENCES
• APPENDIX B MAINTENANCE ALLOCATION CHART
• Section II. MAINTENANCE ALLOCATION CHART
• Section II. MAINTENANCE ALLOCATION CHART - CONT
• Section III. SPECIAL TOOLS AND TEST EQUIPMENT
• Section IV. SUPPLEMENTARY INSTRUCTIONS
• APPENDIX C BASIC ISSUE ITEMS LIST, ITEMS TROOP INSTALLED OR AUTHORIZED LIST
• Section II. BASIC ISSUE ITEMS LIST
• INDEX
• INDEX - CONT
• INDEX - CONT
• RECOMMENDED CHANGE TO EQUIPMENT TECHNICAL PUBLICATION
• TM-10-3930-630-12
• BLANK PAGE
• By Order of the Secretary of the Army: