|
| |
- TECHNICAL MANUAL
- WARNING
- OPERATOR AND ORGANIZATIONAL
MAINTENANCE MANUAL
- OPERATOR AND ORGANIZATIONAL
MAINTENANCE MANUAL
- By Order of the Secretary of
the Army:
- TECHNICAL MANUAL
- TABLE OF CONTENTS
- TABLE OF CONTENTS
- CHAPTER 1 INTRODUCTION
- Figure 1-1. Rough terrain
forklift truck, right front three-quarter view with shipping
dimensions.
- Figure 1-2. Rough terrain
forklift truck, left rear, three-quarter view.
- FIGURE 1-3. Wiring Diagram
- CHAPTER 2 OPERATING
INSTRUCTIONS
- Figure 2-1. Controls and
instruments.
- Starting
- Operation of Equipment
- Figure 2-.3 Driving on
improued surfaces.
- Figure 2-4. Driving in surf
- Figure 2-.5. Driving in sand
or snow.
- Figure 2-6. Picking up load
on improved surfaces.
- Figure 2-7. Picking upload
on unimproved surfaces.
- Figure 2-8. Depositing load.
- Figure 2-9. Forklifts
topping instructions.
- Section II. OPERATION UNDER
UNUSUAL CONDITIONS
- operation in Dusty or Sandy
Area
- CHAPTER 3 OPERATOR/CREW
MAINTENANCE INSTRUCTIONS
- Figure 3-1. LO
10-3930-242-12-1/2 (Sheet 1 of 4)
- Figure 3-1. LO
10-3930-242-12-1/-2 (Sheet 2 of 4)
- Figure 3-1. LO
10-3930-242-12-1/-2 (Sheet 3 of 4)
- Figure 3-1. LO
10-3930-242-12-1/-2 (Sheet 4 of 4)
- SECTION II. OPERATOR/CREW
PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
- Table 3-1. Operator/Crew
Preventive Maintenance Checks and Services
- Table 3-1. Operator/Crew
Prventive Maintenance Checks and Services - Continued
- Tabel 3-1. Operator/Crew
Preventive Maintenance Checks and Services - Continued
- Tabel 3-1. Operator/Crew
Preventive Maintenance Checks and Services - Continued
- Tabel 3-1. Operator/Crew
Preventive Maintenance Checks and Services - Continued
- Table 3-2. Operator/Crew
Troubleshooting
- Figure 3-2. Ether primer
servicing,
- Figure 3-3. Battery.
- ORGANIZATIONAL MAINTENANCE
INSTRUCTIONS
- Section III. REPAIR PARTS,
SPECIAL TOOLS AND EQUIPMENT
- Table 4-1. Organizational
Preventive Maintenance Checks and Services
- Table 4-1. Organizational
Preventive Maintenance Checks and Services-Continued
- Section V. TROUBLESHOOTING
- Table 4-2. Organizational
Troubleshooting-Continued
- Figure 4-1. Oil filter,
removal and installation.
- Figure 4-3. Crankcase
breather, removal and installation.
- Section VII. MAINTENANCE OF
EXHAUST SYSTEM
- Section VIII. MAINTENANCE OF
FUEL SYSTEM
- Engine Air Cleaner
- Figure 4-7. Air cleaner
servicing.
- Figure 4-8 Air cleaner
assembly, removal and installation.
- Figure 4-9. Fuel filters,
removal and installation.
- Section IX. MAINTENANCE OF
COOLING SYSTEM
- Thermostat Housing and
Thermostat
- Figure 4-12. Waterpump and
pulley, removal and installation.
- Coolant Hoses and Fittings
- Drive Belts
- Figure 4-16. Drive belts,
removal and installation.
- Fan Blade
- Section X. MAINTENANCE OF
ELECTRICAL SYSTEM
- Figure 4-20. Engine
generator and voltage regulator, one-equipment testing.
- Battery Holddown Cover,
Batteries, and Cables
- Voltage Regulator and
Bracket
- Figure 4-25. Starter and
solenoid, removal and installation.
- Figure 4-26. Neutral starts
witch, removal, installation, and adjustment.
- Brake Pressure Switch.
- Figure 4-28. Starter
pressure switch and magnetic switch.
- Figure 4-29. Stoplights,
blackout lights, headlights, horn and taillights, removal and
installation.
- Floodlights
- Section XI. MAINTENANCE OF
CONTROLS AND INSTRUMENTS
- Light Switch
- Figure 4-31. Controls and
instruments, removal and installation.
- Foot Controls
- Section XII. MAINTENANCE OF
TRANSMISSION
- Transmission Oil Level Check
Plug
- Section XIII. MAINTENANCE OF
PROPELLER SHAFT
- Section XIV. MAINTENANCE OF
BRAKES
- Slack Adjusters and Llnes
- Brake Accumulator
- Section XV. MAINTENANCE OF
WHEELS
- Section XVI. MAINTENANCE OF
STEERING SYSTEM
- Section XVII. MAINTENANCE OF
HOOD AND BODY
- Figure 4-42. Roll
overprotective structure (ROPS), removal and installation.
- Seat
- Figure 4-43. Seat removal
adjustment, and installation. (Army models MHE 200 and MHE 202).
- Counterweight and Pintle
Hook.
- Section XVIII. MAINTENANCE
OF HYDRAULIC LIFT, PUMP, AND TUBING
- Side Shift Roller Chain,
Cylinder,
- Contamination Indicator
- Hydraulic Hoses
- Figure 4-49. Installing high
pressure hose fittings.
- APPENDIX A REFERENCES
- BLANK PAGE
- APPENDIX B COMPONENTS OF END
ITEM LIST
- APPENDIC C ADDITIONAL
AUTHORIZATION LIST
- APPENDIX D MAINTENANCE
ALLOCATION CHART
- Explanation of Columns in
the MAC, Section II
- Section II. MAINTENANCE
ALLOCATION CHART
- Section II. MAINTENANCE
ALLOCATION CHART - CONT
- Section II. MAINTENANCE
ALLOCATION CHART - CONT
- Section II. MAINTENANCE
ALLOCATION CHART - CONT
- Section II. MAINTENANCE
ALLOCATION CHART - CONT
- Section II. MAINTENANCE
ALLOCATION CHART - CONT
- Section II. MAINTENANCE
ALLOCATION CHART - CONT
- Section II. MAINTENANCE
ALLOCATION CHART - CONT
- Section II. MAINTENANCE
ALLOCATION CHART - CONT
- Section II. MAINTENANCE
ALLOCATION CHART - CONT
- Section II. MAINTENANCE
ALLOCATION CHART - CONT
- Section III. TOOL AND TEST
EQUIPMENT REQUIREMENTS
- APPENDIX E REPAIR PARTS AND
SPECIAL TOOLS LIST
- APPENDIX F EXPENDABLE
SUPPLIERS AND MATERIALS LIST
- INDEX
- INDEX - CONT
- BLANK PAGE
- BLANK PAGE
- TM-10-3930-242-12
- RECOMMENDED CHANGE TO
EQUIPMENT TECHNICAL PUBLICATION
- BLANK PAGE
- RECOMMENDED CHANGE TO
EQUIPMENT TECHNICAL PUBLICATION
- RECOMMENDED CHANGE TO
EQUIPMENT TECHNICAL PUBLICATION
- BLANK PAGE
- BLANK PAGE
- BLANK PAGE
- RECOMMENDED CHANGE TO
EQUIPMENT TECHNICAL PUBLICATION
- BLANK PAGE
- BLANK PAGE
- By Order of the Secretary of
the Army:
- RECOMMENDED CHANGE TO
EQUIPMENT TECHNICAL PUBLICATION
- BLANK PAGE
- BLANK PAGE
- BLANK PAGE
- RECOMMENDED CHANGE TO
EQUIPMENT TECHNICAL PUBLICATION
- By Order of the Secretary of
the Army:
- BLANK PAGE
- BLANK PAGE
- BLANK PAGE
- RECOMMENDED CHANGE TO
EQUIPMENT TECHNICAL PUBLICATION
- BLANK PAGE
|
|
Click
here for thousands of PDF manuals