Tabel 3-1. Operator/Crew Preventive Maintenance Checks and Services - Continued

TM10-3930-242-12

Table 3-I. Operator/Crcw preventive Maintenance Checks and SemitesConthwed

NOTE: Within designated Interval, these checks are to be

performed in the order listed.

B-Before

D-During

A-After

W-Weekly

Item To Be Inspected

Interval

Procedure: Check for and have repaired, filled, or

Equipment is not Ready

Item

adjusted as needed.

Available If:

DAW

No.

RADIATOR

WARNING

Pressurized cooling system. Remove cap

slowly and only when engine is cool or pain-

fud burns could result.

Radiator obviously low or

Visually check coolant level and ensure that coolant

empty. Refer to instrument

is 1-1/2 to 2 inches below neck.

checks.

FUEL SYSTEM

CAUTION

In freezing weather, drain water from pri-

mary falter after operation or damage to

equipment could result.

Drain water and contaminants from primary falter.

Frozen water in fuel system could cause damage to

equipment.

Section III. TROUBLESHOOTING

actions. If a malfunction is not listed or is not

3-5. General

corrected by listed corrective actions, notify your

a . This section contains troubleshooting

supervisor.

information for locating and correcting most of the

c. Table 3-2 lists the common malfunctions which

operating troubles which may develop in the rough

you may find during the operation or maintenance of

terrain forklift truck. Each malfunction for an

the rough terrain forklift truck or its components.

individual component, unit, or system is followed by

You should perform the tests or inspections and the

a list of tests or inspections which will help you to

corrective actions in the order listed.

determine corrective actions to take. You should

perform the tests or inspections and corrective

NOTE

actions in the order listed.

Before you use this table, be sure you have

b. This manual cannot list all malfunctions that

performed all applicable operating checks.

may occur, nor all tests or inspections and corrective

3-8.3