Click here to make tpub.com your Home Page

Page Title: Home Page

• DEPARTMENT OF THE ARMY TECHNICAL MANUAL
• DANGEROUS GASES
• OPERATOR AND ORGANIZATIONAL MAINTENANCE MANUAL
• OPERATOR AND ORGANIZATIONAL MAINTENANCE MANUAL
• TABLE OF CONTENTS
• LIST OF ILLUSTRATIONS
• LIST OF ILLUSTRATIONS-Continued
• LIST OF TABLES
• CHAPTER 1 INTRODUCTION
• Figure 1-1. Fork Lift Truck, Right Side View
• Tabulated Data
• Tabulated Data - CONT
• Figure 1-3. Wiring Diagram
• Differences in Models
• CHAPTER 2 OPERATING INSTRUCTIONS
• Stopping
• Driving Truck
• Driving With a Load
• Operation in Salt Water Areas
• CHAPTER 3 OPERATOR/CREW MAINTENANCE INSTRUCTIONS
• Table 3-1. Operator/Crew Preventive Maintenance Checks and Services
• Table 3-1. Operator/Crew Preventive Maintenance Checks and Services - Continued
• Figure 3-1. Engine Crankcase Dipstick Location
• Section III. TROUBLESHOOTING
• Table 3-3. Troubleshooting
• CHAPTER 4 ORGANIZATIONAL MAINTENANCE INSTRUCTION'
• Detailed Lubrication Information
• Table 4-1. Organizational Preventive Maintenance Checks and Services
• Section VI. TROUBLESHOOTING
• Table 4-2. Troubleshooting-Continued
• Table 4-2. Troubleshooting-Continued
• Table 4-2. Troubleshooting-Continued
• Table 4-2. Troubleshooting-Continued
• Table 4-2. Troubleshooting-Continued
• Table 4-2. Troubleshooting-Continued
• Table 4-2. Troubleshooting-Continued
• Table 4-2. Troubleshooting-Continued
• Table 4-2. Troubleshooting-Continued
• Section VII. RADIO INTERFERENCE SUPPRESSION
• Figure 4-1. Interference Suppression Components, Removal and Installation, Sheet 1
• Section VIII. OVERHEAD GUARD AND FLOOR PLATE
• Section IX. OPERATOR'S SEAT
• Figure 4-3. Operator's Seat
• Section X. BODY PANELS AND HOODS
• Figure 4-4. Body Panels and Hoods
• Section XI. INSTRUMENT PANEL AND INSTRUMENTS
• Section XII. HYDRAULIC LIFT COMPONENTS
• Tilt Cylinder
• Hydraulic Lift Chain
• Figure 4-9. Lift Chain, Removal and Installation
• Hydraulic Lines and Fittings
• Figure 4-11. Hydraulic Lines, Removal and Installation
• Hydraulic Oil Tank and Filter.
• Figure 4-12. Hydraulic Oil Filter, Disassembly and Reassembly
• Section XIII. ELECTRICAL SYSTEM
• Voltage Regulator
• Figure 4-15. Voltage Regulator, Cover Removed
• Table 4-3. Temperature-Voltage and Temperature-Current Chart for Adjusting Voltage Regulator
• Test and adjust the current regulator as
• Starter Motor
• Ignition Distributor
• Figure 4-21. Distributor, Disassembly and Reassembly
• Spark Plugs
• Ignition Coil
• Battery and Cables
• Lights
• Figure 4-27. Taillight, Disassembly and Reassembly
• Section XIV. FUEL SYSTEM
• Figure 4-28. Positive Crankcase Ventilation Valve and Piping
• Figure 4-29. Carburetor, Adjustment Points, Removal and Installation
• Fuel Pump
• Air Cleaner
• Crankcase Breather
• Governor Adjustment
• Accelerator Pedal and Linkage
• Cleaning and Inspection.
• Section XV. COOLING SYSTEM
• Figure 4-36. Cooling System, Disassembly and Reassembly
• Figure 4-37. Reverse Flushing the Radiator
• Thermostat
• Water Pump and Fan Blade
• Figure 4-40. Water Pump and Fan Blade, Removal and Installation
• Section XVI EXHAUST SYSTEM
• Section XVII. STEERING SYSTEM
• Figure 4-42. Drag Link, Disassembly and Reassembly
• Tie Rods
• Section XVIII. MAINTENANCE OF ENGINE
• Engine Oil Filter
• Intake and Exhaust Manifold
• Section XIX. WHEELS AND TIRES
• Section XX. BRAKES
• Hand Brake Lever Replacement
• Service Brakes
• Figure 4-54. Pressure Bleeding Setup
• Manual Bleeding.  Manual bleeding
• Brake Master Cylinders
• Cleaning and Inspection.
• Brake Pedal and Linkage
• Section XXII. TRANSMISSION
• Direction Shift Lever and Linkage Adjustment
• Figure 4-61. Directional Shift Lever and Linkage
• APPENDIX A REFERENCES
• APPENDIX B MAINTENANCE ALLOCATION CHART
• Explanation of Columns in the MAC, Section II
• Section II. MAINTENANCE ALLOCATION CHART
• Section II. MAINTENANCE ALLOCATION CHART - CONT
• Section II. MAINTENANCE ALLOCATION CHART - CONT
• Section II. MAINTENANCE ALLOCATION CHART - CONT
• Section II. MAINTENANCE ALLOCATION CHART - CONT
• Section II. MAINTENANCE ALLOCATION CHART - CONT
• Section III. TOOL AND TEST EQUIPMENT REQUIREMENTS
• APPENDIX BASIC ISSUE ITEMS LIST AND ITEMS TROOP INSTALLED OR AUTHORIZED LIST
• INDEX
• INDEX - CONT
• INDEX - CONT
• INDEX - CONT
• INDEX - CONT
• TM-10-3930-632-12
• BLANK PAGE
• By Order of the Secretary of the Army:
• By Order of the Secretary of the Army:
• RECOMMENDED CHANGE TO EQUIPMENT TECHNICAL PUBLICATION