Battery Cables and Batteries (cont). - TM-10-3930-638-24-P0221

TM 10-3930-638-24&P

2-33. BATTERY SYSTEM MAINTENANCE (cont)

h. Battery Cables and Batteries (cont).

STEP

LOCATION

ITEM

ACTION

REMARKS

REMOVAL

Battery compart- a. Ground cable

Remove from

Loosen clamp nut, spread clamp terminal

ment, rear of

clamp (1)

battery post

and lift from battery post

vehicle

b. Battery cable clamps

Remove from

Loosen clamp nuts, spread clamp

(3) and positive

battery posts

terminals and lift from battery posts

cable (2)

c. Two cap screws (4)

Loosen and

remove

d. Two hold-down

Remove

Lift from batteries

straps (5)

e. Two batteries (6)

Remove

Lift from battery compartment

f. Positive cable

Remove

From starter solenoid B terminal

terminal (7)

(para 2-27a)

g. Ground cable

Remove

From starter housing (para 2-27a)

terminal (8)

h. Nut (9), lock washer

Remove

From clamp (12)

(10) and cap screw (11)

i. Clamp (12)

Remove

Spread and lift from harness and battery

cables

j. Two grommets (13)

Remove

and cables (1 and 3)

CLEANING

WARNING

Dry cleaning solvent (P-D-680), used to clean parts is toxic and

flammable. Wear protective goggles and gloves and use only in a

well ventilated area. Avoid contact with skin, eyes, and clothes

and don't breathe vapors. Do not use near open flame or

excessive heat and don't smoke when using it. Failure to do so

could cause serious injury. If you become dizzy while using

cleaning solvent, get fresh air immediately, and get medical

attention. If contact with skin or clothes is made, flush with large

amounts of water. If contact with eyes is made, wash eyes with

water immediately, and obtain medical aid immediately.

WARNING

Wear safety glasses when drying parts with compressed air.

Failure to do so could cause serious injury to eyes and possible

blindness. If you hurt your eyes or if a foreign object is blown

into your eyes, seek medical attention immediately.

Clean

Use cleaning solvent P-D-680.

Straps (5), clamp (12)

Dry thoroughly with compressed air

and hardware

Wipe with a clean, dry cloth

Clean

Cables (1, 2 and 3) and

grommet (13)

2-185