Chapter 1. INTRODUCTION - TM-10-3930-243-340021

CHAPTER 1

INTRODUCTION

Section I. GENERAL

1-1. Scope

maintenance will be only those prescribed in TM

38-750.

These instructions are published for the use of

b. Report of errors, omissions and recoin -

d i r e c t support and general support personnel

mendations for improving this publication by the

maintaining the Pettibone-Mulliken Model RTL10

individual user is encouraged. Reports should be

and Model RTL10-1 forklift trucks. They provide

s u b m i t t e d on DA Form 2028 (Recommended

information for the maintenance of the equipment

Changes to Publications) and forwarded direct

which is beyond the scope of the tools, equipment,

to Commanding General, U. S. Army Mobility

personnel, or supplies normally available to using

Equipment Command, ATTN: AMSME-MPP,

organizations.

4300 Goodfellow Boulevard, St. Louis, Mo. 63120.

1-2. Forms and Records

a. DA forms and records used for equipment

Section II. DESCRIPTION AND DATA

1-3. Description

T y p e .... .... .... ......... V

Cylinders . . . . . . . . . . ........6

A general description of the forklift truck, the

Cycle . . . . ... . . . . ..........2

location and description of the identification and

Bore. .. . . . . . . . . . . . . . . . . . ..3.875 in.

instruction plates, and information on the dif-

Stroke .................... 4.5 in.

ference in models are contained in TM 10-3930-

Compression ratio (nominal) 17 to 1

Displacement . . . . . . . . .. .. .. 318.6 cu. in.

243-12. Paragraphs throughout the manual will

Firing order . . . . . . . . . . . . . . . 1L-3R-3L-2R-2L-1R

indicate difference between the two models by

Rotation . . . . . . . . . . . . . . . . . . Clockwise

applicable model numbers. The repair and

Idle speed. ... .... .... 500 to 600 rpm

maintenance instructions for direct support and

Governed speed (no load) . ..3010 rpm

general support maintenance personnel are

O i l pressure............... 40 to 60 psi at 2800 rpm

Minimum oil pressure . . . . . . . 30 psi

described in the appropratie sections of this

d. Generator.

manual.

1-4. Tabulated Data

Manufacturer, ... ......... Delco-Remy (Model RTL10)

P a r t No, .... ... ... .. ......1117495

a. General. This paragraph contains overhaul

Rating . . . . . . . . . . . . ..24 V, DC

data pertinent to direct and general support

Manufacturer . .. . . . . . .. . . .. Prestolite (Model RTL10-1)

maintenance personnel.

P a r t No... ... ... .... .... GHA4808UT

b. General

Rating . . . . . . . . . . . . ..24 V, DC

Manufacturer . . . . . . . . . . . . . . Pettibone-Mulliken Corp.

e. Generator Regulator.

Models . . . . . . . . . . . . . . . . . . . RTL10 and RTL10-1

Manufacturer, .. .......... Delco-Remy

Length . . . . . . . . . . . . . . . . . . ..203 in.

Part No. . . . . . . . . . . . . . . . . . 1118656

Width. . . . . . . . . . . . . . . . . . . 106 in.

Rating . . . . . . . . . . . . . . . . . . . 24 V, DC, 25amp

Height . . . . . . . . . . . . . . . . . . . . 133 in,

Ground ,, ,. . . . . . . . . . . . . . . Negative

Shipping weight ... . ..,... 34,500 lbs.

cube. . . . . . . . . . . . . . . . . . . . . 1505-0 ft.

f. Starter.

Load center . . . . . . . . . . . . . . . 24 in.

Manufacturer . . . . . . . . . . . . . Delco-Remy

Drawbar pull . . . . . . . . . . . . ..l9,000 lbs.

Part No . . . . . . . . . . . . . . . . . . 1113847

Maximum fording depth . . . . 5 ft. to crest of wave

Rating . . . . . . . . . . . . . . . . . ..24 V, DC

Capacity . . . . . ..-... ....... 10,000 lbs.

Transmission with Torque Converter.

c. Engine.

Manufacturer . . . . . . . . . . . . . Allison Div., General Motors

Manufacturer . . . . . . . . . . . . . Detroit Diesel Engine Div.,

Corp.

General Motors Corp.

Model . . . . . . . . . . . . . . . . . . .. CRT 3531-1

Mode . . . . . . . . . . . . . . . . . . . 5063-5200

Beads . . . . . . . . . . . . . . . . . . . . 53

1-1