Click here to make tpub.com your Home Page

Page Title: Home Page

• OPERATOR'S AND ORGANIZATIONAL MAINTENANCE MANUAL
• WARNING
• Operator and Organizational Maintenance Manual
• Operator and Organizational Maintenance Manual
• Table 3-1. Maintenance and Operating Supplies
• APPENDIX B BASIC ISSUE ITEMS UST AND ITEMS TROOP INSTALLED OR AUTHORIZED
• Section III. ITEMS TROOP INSTALLED OR AUTHORIZED LIST
• WARNING
• TABLE OF CONTENTS
• LIST OF ILLUSTRATIONS
• Figure i. FJF-040 Fork Lift Truck
• SECTION I INTRODUCTION AND GENERAL DESCRIPTION
• Figure 1-2. Typical Engine, Front and Rear Views
• Figure 1-3. Charging System Basic Schematic
• Figure 1-4. Hydraulic System Diagram
• HYDRAULIC PUMP
• DRIVE AXLE
• Figure 1-6. Power Steering Gear Operation
• Figure 1-7. Transmission, Showing Pressure Passages
• ELECTRICAL SYSTEM COMPONENTS.
• IGNITION SWITCH.
• Figure 1-10. Uprights, Carriage and Fork
• Figure 1-11. Electrical Schematic
• Figure 1-12. Instrument Panel'
• SECTION II TABLE OF SPECIFICATIONS
• TABLE OF SPECIFICATIONS
• TABLE OF SPECIFICATIONS
• TABLE OF SPECIFICATIONS
• TABLE OF SPECIFICATIONS
• TABLE OF SPECIFICATIONS
• SECTION III PREPARATION FOR USE
• Table 3-1. Maintenance and Operating Supplies
• Figure 3-1. Check Points Before Use
• OPERATIONAL CHECKOUT
• SECTION IV OPERATION
• FUEL TANK.
• IGNITION SYSTEM
• Figure 4-1.1. Fuel tank components, exploded view.
• Figure 4-2. Ignition System Schematic
• PUMP  CIRCULATING
• THERMOSTAT
• CHARGING SYSTEM
• Figure 4-4. Differential Diagram
• Figure 4-5. Transmission Power Flow
• WHEEL BRAKES
• OPERATING INSTRUCTIONS.
• OPERATING INSTRUCTIONS-cont.
• Figure 4-6. Wheel Brake Layout
• Figure 4-6.1. Front Drive Axle Complete, Exploded View
• Figure 4-6.2. Hand Brake Control Installation, Exploded View
• Figure 4-7. Instruments and Controls
• OPERATING PROCEDURES AND TECHNIQUES
• SAFETY PRECAUTIONS
• SECTION V INSPECTION, MAINTENANCE AND LUBRICATION
• Figure 5-2. Cylinder Head Tightening Sequence
• PREVENTIVE MAINTENANCE CHECKS AND SERVICES
• PREVENTIVE MAINTENANCE CHECKS AND SERVICES-CONT.
• PREVENTIVE MAINTENANCE CHECKS AND SERVICES
• CYLINDER HEAD
• Figure 5-2.1. Accelerator pedal and linkage, exploded view
• AIR CLEANER SERVICING
• LEAKAGE TESTS
• DISTRIBUTOR MAINTENANCE.
• Figure 5-5. Breaker Plate
• Figure 5-6. Breaker Point Adjustment
• CHARGING SYSTEM MAINTENANCE
• Figure 5-12. Alternator Test Setup
• BATTERY SPECIFIC GRAVITY TEST
• STEERING LINKAGE ADJUSTMENT
• TABLE 5-1. SERVICE TROUBLES AND REMEDIES
• TABLE 5-1. SERVICE TROUBLES AND REMEDIES (Cont'd)
• TABLE 5-1. SERVICE TROUBLES AND REMEDIES (Cont'd)
• TABLE 5-1. SERVICE TROUBLES AND REMEDIES (Cont'd)
• TABLE 5-1. SERVICE TROUBLES AND REMEDIES (Cont'd)
• TABLE 5-1. SERVICE TROUBLES AND REMEDIES (Cont'd)
• TABLE 5-1. SERVICE TROUBLES AND REMEDIES (Cont'd)
• TABLE 5-1. SERVICE TROUBLES AND REMEDIES (Cont'd)
• TABLE 5-1. SERVICE TROUBLES AND REMEDIES (Cont'd)
• TABLE 5-1. SERVICE TROUBLES AND REMEDIES (Cont'd)
• Figure 5-14. Test Equipment
• TABLE 5-2. TEST EQUIPMENT LIST
• SECTION VI REMOVAL AND INSTALLATION OF ASSEMBLIES
• Figure 6-1. Fork Lift Truck Components
• FLOOR PLATE INSTALLATION.
• Figure 6-2. Hydraulic System Layout
• Figure 6-2.1. Hydraulic Hoist and Tilt Control Valve, Exploded View
• LIFT CHAINS
• ELECTRICAL SYSTEM
• DISTRIBUTOR INSTALLATION
• NEUTRAL SAFETY SWITCH INSTALLATION
• POWER TRAIN
• STEERING GEAR.
• Figure 6-5. Steering Gear Removal
• HYDRAULIC BRAKE MASTER CYLINDER.
• Figure 6-6. Hydraulic Brake Master Cylinder and Pedal Assembly, Exploded View
• EXHAUST HOSE
• Figure 6-7. Muffler, exhaust pipe and exhaust hose, exploded view.
• Figure 6-8. Engine Assembly
• Figure 6-9. Hydraulic System Line Filter, Exploded View
• APPENDIX A MAINTENANCE ALLOCATION CHART
• Explanation of Columns in Section II.
• Explanation of Columns in Section II.-CONT.
• SECTION II - MAINTENANCE ALLOCATION CHART
• SECTION II - MAINTENANCE ALLOCATION CHART
• SECTION II - MAINTENANCE ALLOCATION CHART
• SECTION II - MAINTENANCE ALLOCATION CHART
• SECTION II - MAINTENANCE ALLOCATION CHART
• SECTION II - MAINTENANCE ALLOCATION CHART
• SECTION II - MAINTENANCE ALLOCATION CHART
• SECTION II - MAINTENANCE ALLOCATION CHART
• SECTION II - MAINTENANCE ALLOCATION CHART
• SECTION II - MAINTENANCE ALLOCATION CHART
• APPENDIX B BASIC ISSUE ITEMS UST AND ITEMS TROOP INSTALLED OR AUTHORIZED
• BLANK PAGE
• TM-10-3930-623-12
• Distribution
• Distribution