EXPECTED TEMPERATURES - LO-10-3930-611-120002

LUBRICANT INTERVAL

INTERVAL LUBRICANT

Mast Assembly

Mast Pivot Pin

(Sparingly)

Tilt Cylinder

Pivot Pin

(Sparingly)

Drag Link

Brake Master Cylinder

(Sparingly)

Fill and Level

(Check level)(See key.)

Tilt Cylinder

Pivot Pin

(Sparingly)

Hydraulic Oil Line

Filter

Hydraulic Oil Reservoir

(Replace element)

Fill and level Cap

(See note 2)

(Correct level is 3

inches below fill

neck, fluid must

be visible in bottom

of screen.)

FOLD

-KEY-

EXPECTED TEMPERATURES

LUBRICANTS

CAPACITY

Above +32 F +40 F to -10 F 0 F to -65 F

INTERVALS

OE-OIL, Engine, Heavy Duty

Oil Can Points

OE 10

OES

Hydraulic Oil Reservoir

68 qt

Intervals

OES-OIL, Engine, Sub-zero

given are

GO-LUBRICATING OIL, Gear

in hours

Differential

2 qt

GO 90

GOS

of normal

Steering Gear

1 pt

operation

GOS-LUBRICATING OIL, Gear, Sub-zero

HB-BRAKE FLUID, Automotive

Brake Master Cylinder

5/16 qt

ALL TEMPERATURES

GAA-GREASE, Automotive and Artillery

NOTES:

1. FOR OPERATION OF EQUIPMENT IN PROTRACTED

4. LUBRICANTS. The following is a list of lubricants

COLD TEMPERATURES BELOW-10F. Remove lubric-

with the Military Symbols and the applicable

ants prescribed in the key for temperatures above -10F.

Specification numbers.

Relubricate with lubricants specified in the key for

OE-MIL-L-2104

HB-FED SPEC VV-B-680

temperatures below-10F.

OES-MIL-L-10295 GAA-MIL-G-1 0924

GO-MIL-L-2105

GOS-MIL-L-1 0324

Copy of this Lubrication Order will remain with the

2. HYDRAULIC SYSTEM. Every 50 hours check oil level.

equipment at all times; instructions contained herein are

Every 500 hours drain reservoir, replace line filter element,

mandatory.

clean sump strainer, reinstall drain plug. Fill reservoir,

BY ORDER OF THE SECRETARY OF THE ARMY:

operate lift for 5 minutes, check for leaks, check oil level

W. C. WESTMORELAND

and bring to 3 inches below fill neck.

General, United States Army,

Chief of Staff.

OFFICIAL:

3. OIL CAN POINTS. Every 50 hours, clean and lightly

KENNETH G. WICKHAM

coat all linkages and exposed adjusting threads, oil lift chain

Major General, United States Army

and chain coupler with OE.

The Adjutant General

LO 10-3930-611-12 DISTRIBUTION: To be distributed in accord-

ance with DA Form 12-25, Sec I (qty rqr Block #190), Organization-

al maintenance requirement, for Truck, Forklift: Electrical.

GPO 816-710