AIR CLEANER - LO-10-3930-238-120005

LO 10-3930-238-12

NOTES - CONTINUED:

other friction points, not equipped with oil cups or

11. CHAIN. Each 250 hours, wire brush clean and

pressure fittings, with OE/HDO.

brush on OE/HDO .

12. LUBRICANTS. The following is a list of lubricants

3. AIR CLEANER. Each 250 hours disassemble unit,

with military symbols and applicable specification

clean, assemble and refill with OE/HDO.

numbers.

4. HYDRAULIC TANK. Each 50 hours check level.

OE/HDO

MIL-L-2104

Each 1000 operating hours drain tank and refill with

MIL-L-2105

OE/HDO 10.

GAA

MIL-G-10924

OEA

MIL-L-46167

After refill, operate for 5 minutes, check for leaks and

BFS

MIL-B-46176

bring to "FULL" mark.

(SD), Type II

P-D-680

5. CRANKCASE VENTILATING CHECK VALVE. Each

250 hours remove valve and clean in drycleaning

solvent.

6. DISTRIBUTOR. Each 250 operating hours, remove

rotor and apply OE/HDO sparingly to felt wick in center

of cam. Do not over oil and keep oil from contact points.

7. TRANSMISSION. Check level each 10 hours with

engine running at idle speed, oil at operating

temperature and transmission in neutral. Maintain oil

level to "FULL" mark. Each 1000 operating hours, drain

and refill with OE/HDO 10. Fill to "LOW" mark. Run

engine to fill converter and lines. Add oil to bring level to

Copy of this Lubrication Order will remain with the

"LOW" mark. With engine running at idle speed, oil at

equipment at all times, instructions contained herein are

operating temperature and transmission in neutral, add

mandatory.

oil to bring level to "FULL" mark. Operate for 5 minutes

and check for leaks.

By order of the Secretary of the Army:

JOHN A. WICKHAM, JR.

8. ENGINE OIL LEVEL HOT OR COLD CHECK. Cold

General, United States Army

engine, oil level should be at high mark on dipstick. Hot

Chief of Staff

engine, oil level must be between high and low marks on

OFFICIAL:

dipstick (allow to set 5 minutes before checking).

ROBERT M. JOYCE

Major General, United States Army

9. CRANKCASE. Oil is to be changed each 250

The Adjutant General

operating hours. Drain when oil is warm.

DISTRIBUTION:

To be distributed in accordance with DA Form 12-

10. ENGINE OIL FILTER. Each 250 operating hours,

25A, Operator and Organizational maintenance

remove filter cartridge, clean housing and install new

requirements for Forklift Trucks

filter cartridge. After installing new filter cartridge, fill

crankcase, operate engine for 5 minutes, check for

leaks, check oil level and bring to "FULL" mark.

I U.S. GOVERNMENT PRINTING OFFICE: 1984-420-903/230

TA220088

CARD 5 OF 6